DAB retrofit to 2010 E91

DAB retrofit to 2010 E91

Author
Discussion

eatontrifles

Original Poster:

1,442 posts

233 months

Thursday 5th June 2014
quotequote all
After much searching, reading and speaking to various different people (retrofitters, suppliers, BMW parts guys and BMW genius guys) I've finally ordered a module to retrofit DAB to my E91 with CIC professional nav; http://www.kufatec.co.uk/shop/en/fistune-dab-solut...
It's only been available for a week or so, the suppliers told me a few months ago that the delay was due to the development of a USB coding dongle which programmes the head unit to accept the module (bit vague this bit).

It uses the cabling for the CD changer and emulates the changer itself as a media device - each disk is the DAB ensemble and each track on the disk is the DAB station. There's a quick vid here of one installed in an Audi; https://www.youtube.com/watch?v=CminyQbpqq4

My next step is to find out how to get the signal into it - ideally I want to use the BMW aerial which if I'm lucky just requires an amplifier - part number 65206933328 @£75 or so plus some cables. If I'm unlucky I may need the amplifier plus a new aerial. I suspect the factory DAB aerial is in the rear side glass so if that's the case I'll be looking at other options, probably an internal glass mount aerial to fit instead.

I'll keep the thread updated and would appreciate any info that others may have to add. smile

eatontrifles

Original Poster:

1,442 posts

233 months

Tuesday 15th July 2014
quotequote all
Nobody on PH is bothered then? wink

To update - I have now fitted the DAB module and it's all working fine.

The MOST fibre factory prewiring for the CD changer is not connected and is on a loopback - I had no idea where that cable went to so I ended up using the connections at the combox under the boot floor instead. I installed an Autoleads DAB-001 glass film aerial on the rear side window and ran the cable from it to the Fistune module - the SMB connection of the aerial fits in the Fakra connection on the module.

A few pics below;





Moily

167 posts

140 months

Tuesday 15th July 2014
quotequote all
Nice! That looks a better solution than the official BMW retrofit which doesn't even integrate with the iDrive. Not to mention cheaper, if fitted yourself.

How long did it take you to fit? I have an E93 so would need to run the aerial all the way to the front windscreen, which sounds like a ballache.




eatontrifles

Original Poster:

1,442 posts

233 months

Tuesday 15th July 2014
quotequote all
Moily said:
Nice! That looks a better solution than the official BMW retrofit which doesn't even integrate with the iDrive. Not to mention cheaper, if fitted yourself.

How long did it take you to fit? I have an E93 so would need to run the aerial all the way to the front windscreen, which sounds like a ballache.
You could quite easily fit the Fistune module at the front of the car as there's a MOST cable to the head unit as well as a break point in the chain under the glovebox that you could use. The Fistune comes with fibre cables which allow you to insert the module in series into the MOST bus. All you need to do then is find power (I used the CD changer power but finding ignition switched +12V at the front shouldn't be a problem) and run the aerial up the A pillar, which is pretty much the same as I've done but at the front of the car instead.

The most difficult bits were working out that the CD changer cabling was on a loopback and then working out how to take off & put back the trim properly - gap openers really helped! The rest was a doddle and pretty much plug & play.

Edited by eatontrifles on Tuesday 15th July 16:12

Moily

167 posts

140 months

Tuesday 15th July 2014
quotequote all
Ah great, I'll take a look at the weekend to see what's there.

How do you tune the module via iDrive, by the way?

eatontrifles

Original Poster:

1,442 posts

233 months

Tuesday 15th July 2014
quotequote all
Moily said:
How do you tune the module via iDrive, by the way?
When you first select the module in the CD changer menu, one of the folders at the bottom of the ensemble list is Autoscan - select it and the Fistune goes off and does a full scan. The stations are saved to its internal memory so you only need to do this once. The only drawback is that if you travel across the country to a different region then you would need to rescan to get the new regional ensembles and since you can't pick up your 'home' ensembles any more, they would disappear until you got back within range and did a new scan - the National ones are as the name describes and you can pick them up anywhere there is coverage. A full scan takes about 30 seconds.
I could do a quick video if you want?

Moily

167 posts

140 months

Tuesday 15th July 2014
quotequote all
That would be sweet, cheers.

So you only have 1 regional ensemble and the national one? I know the factory-fitted DABs have a collection of regional ensembles but it's not a major issue if you have to rescan with this.

anonymous-user

53 months

Tuesday 15th July 2014
quotequote all
Does it continually drop the signal, like the DAB radio on my 2014 F10 does? Sometimes I find it easier to leave it on FM, though it does seem worse in some areas than others.

eatontrifles

Original Poster:

1,442 posts

233 months

Tuesday 15th July 2014
quotequote all
Moily said:
That would be sweet, cheers.

So you only have 1 regional ensemble and the national one? I know the factory-fitted DABs have a collection of regional ensembles but it's not a major issue if you have to rescan with this.
When you do a scan it picks up all the ensembles it can receive at that time - it displays in the same way as the factory fit DAB with the exception that the factory DAB will automatically scan and add a new ensemble as and when it can be received.

There are two 'National' ensembles - BBC National DAB and D1 National, a list of channels in each is here; http://www.wohnort.org/dab/uknat.html
The 'Regional' ensemble map is here; http://www.ofcom.org.uk/static/archive/rau/radio-s... and the list of channels in each is here; http://www.wohnort.org/dab/uknat.html#Regional
To confuse things more there are 'Local' ensembles as well; http://www.wohnort.org/dab/ukloc.html

If (like me) you only ever listen to BBC 6 Music, BBC 5 Live or 5 SportsXtra, TalkSport and occasionally Absolute which are all in National ensembles then you won't need to rescan.

I'll try and remember to do a quick video later.

Edited by eatontrifles on Tuesday 15th July 18:07

eatontrifles

Original Poster:

1,442 posts

233 months

Tuesday 15th July 2014
quotequote all
REALIST123 said:
Does it continually drop the signal, like the DAB radio on my 2014 F10 does? Sometimes I find it easier to leave it on FM, though it does seem worse in some areas than others.
Comparing it to my previous car, to which I fitted a replacement Kinetic DAB aerial it's the same if not better. I've had it drop totally once for around half a second on a BBC National channel when driving past a local taxi firm. The audio has gone 'bubbly' for a second or so once on a Local channel when on a heavily wooded and steep sided road. Both situations to be expected really.

A lot will depend on location, topography and local coverage but on my fairly regular drives across the Pennines and up & down the M/A1 I never experienced a full dropout in the old car so we'll see what happens with this. Certainly on the drive to and from work where I used to get signal loss in a shortish tunnel I now just get a short blip rather than the 2-3 seconds I used to get.

eatontrifles

Original Poster:

1,442 posts

233 months

Tuesday 15th July 2014
quotequote all
A quick video of it working and how it scans. Notice that after I scanned the 'Sheffield' ensemble appears as the last time I scanned (home) it was out of range and that scan was done at work which is a bit closer.

http://www.youtube.com/watch?v=0h2YvdDdydk

Moily

167 posts

140 months

Wednesday 16th July 2014
quotequote all
Looks excellent. Many thanks for taking the time to do that.

Will investigate further how I can get one in my E93 now..!

eatontrifles

Original Poster:

1,442 posts

233 months

Wednesday 16th July 2014
quotequote all
It is pretty good - I'm very happy with it so far. As long as you can find the MOST cables (two cables together, one green and one in a ribbed black cover) and power then it should be fairly simple.

Ranger 6

7,040 posts

248 months

Tuesday 24th February 2015
quotequote all
Dragging this one back up - any long term feedback on the Kufatec box?

I'm looking at getting another BMW and they don't all have the factory DAB, so a decent aftermarket solution would be good.

eatontrifles

Original Poster:

1,442 posts

233 months

Tuesday 3rd March 2015
quotequote all
No problems at all from me. The only major dropout I've had was on a trip to Cornwall and when leaving the A39 and heading to the coast it all went a bit squiffy - a better aerial might have prevented that but the film version I have was easy to install, is fairly discreet and about as OEM as you can get without mucking about with the sharkfin.

As far as the unit & interface goes, it currently displays the DAB ensemble in the disk (or folder) field and the station name in the artist field but the track field is left blank. It would be really nice if that field could be filled with the info that is broadcast with the DAB station that often includes now playing or show info etc etc.
The other minor drawback (for me it isn't a problem) is that it doesn't do an automatic scan for new ensembles as you move around the country, meaning you need to manually scan which overwrites the previously saved channel list. The reason it isn't a problem for me is that I very very rarely listen to any stations which aren't broadcast on a national ensemble and they - obviously - can be picked up nationwide without needing a rescan.

Edited by eatontrifles on Wednesday 4th March 00:08

Ranger 6

7,040 posts

248 months

Wednesday 4th March 2015
quotequote all
Thanks for the feedback - very useful to have it after time in use smile

IforB

9,840 posts

228 months

Saturday 28th March 2015
quotequote all
Great stuff. I'll be following your lead shortly!

Monkey_boy

126 posts

183 months

Thursday 20th August 2015
quotequote all
This is a great thread!

I've been also looking into DAB retrofit too for my E92 and possibly my wifes F11. It seem the Touring models use very different aerial system to the Coupes and Saloons.

From what I've found out the Sharkfin DAB version (65206929346) is only for Band-L frequencies. The Diversity Aerial provides the Band-III frequencies. In the UK we don't have any L-Band DAB radio stations, so if you used the BMW aerials you wouldn't need to replace the sharkfin, just fit a DAB Diversity Amplifier for the Band-III. If you intend on using in Europe then the sharkfin would need to be retrofitted I believe.

For the E92, the DAB Diversity Amplifier part is 65206928935 or 65209187647 which is located just behind the rear roof breaklight - very accessible. The E91 and F11's use a different solution, a cascaded DAB diversity amplifier that plugs into the existing FM Diversity amplifier in the tailgate spoiler. Part number for E91: 65206933328 , F11: 65209199850.
The F11 seems to also have Band-III aerials built into the rear side windows along with the DVB-TV aerials.

I am toying with either Retrofiting a BMW DAB unit to the E92 (probably cheaper - ebay, but no DAB+) or fitting the FISTUNE unit.

Ranger 6

7,040 posts

248 months

Thursday 20th August 2015
quotequote all
Quick update - the car I bought had DAB so no need for a retrofit smile

823

9 posts

68 months

Thursday 26th July 2018
quotequote all
HI smile

I have a bmw f13 year 2013, and It hasn't the dab!

I would add the DAB.

Which is the best choice?

I have seen a lot of video on youtube; Dension dab have too much delay switching the stations.
Fistune seems better!

Is there some other alternatives to consider?

I have not installator of fistune on my country, so I have to buy it and to install it myself.
Is it hard to do?

Have I to remove the original bmw radio to connect the cables in the back?

Or can I do all the work from the trunk without remove the radio/navigation system?


thank you very much


ps. Does my car (bmw f13 2013) equipped with components that are connected by lwl in the trunk ?

Edited by 823 on Thursday 26th July 13:28