Vixen diff numbers

Vixen diff numbers

Author
Discussion

Moto

Original Poster:

1,230 posts

252 months

Tuesday 13th August 2019
quotequote all
Anyone know the original diff fitted to S2 & S3 Vixens ?

Not the cast in casing numbers but the 2 letters which are followed by numbers and stamped in the high point on the very bottom rib of the front casing. It will probably start with FH, FR KC or KD and these determine the differences in ratio, bearing sizes and possibly other more minor differences.

The TVR Owner manual states the diff ratio as 3.89. Was this always the case or did they change at any point?

I ask because mine runs a 'FR' diff which as I understand from researching was fitted to the very last home market Spitfire 1500 cars (my car was the last S3 made, so may tie in with this). But this is a 3.63 ratio? So question is whether this is original or has changed at some point in it's life. If other cars are also running the 'FR' diffs it may suggest it could be original.

Moto

anonymous-user

53 months

Tuesday 13th August 2019
quotequote all
Look on the Canley Classic website its extremely good and has all the diff info in there somewhere. Vixens were FH or FD (I think).

Andrew Gray

4,969 posts

148 months

Tuesday 13th August 2019
quotequote all
Moto said:
Anyone know the original diff fitted to S2 & S3 Vixens ?

Not the cast in casing numbers but the 2 letters which are followed by numbers and stamped in the high point on the very bottom rib of the front casing. It will probably start with FH, FR KC or KD and these determine the differences in ratio, bearing sizes and possibly other more minor differences.

The TVR Owner manual states the diff ratio as 3.89. Was this always the case or did they change at any point?

I ask because mine runs a 'FR' diff which as I understand from researching was fitted to the very last home market Spitfire 1500 cars (my car was the last S3 made, so may tie in with this). But this is a 3.63 ratio? So question is whether this is original or has changed at some point in it's life. If other cars are also running the 'FR' diffs it may suggest it could be original.

Moto
Hi Steve
I thought that they all had 3.89 but i may be wrong.
I suspect all Vixens have had there differentials changed at some point as talking to people who owned them in the 70s and used them as there daily drivers the diff was something they changed a number of times after rummaging around scrap yards getting them out of crashed cars like you could in those days before health and safety put a stop to that fun.
I suspect that most diffs have been re built with stronger internals as the later GT cars had and i would not always go by whats stamped on the casing but pop the car on a ramp and check the ratio manually to confirm.
If your having the diff re built its well worth having the casing drilled and tapped to allow drainage so you can maitain the oil better as well.
Last year i had mine apart and had it stripped checked and a few parts replaced just as a precation but concidering the treatment it gets its doing very well and never had an issue touch wood.
Andrew

foxdog

156 posts

241 months

Tuesday 13th August 2019
quotequote all
Hi steve its not the original diff I blew that up on my first practise run in 1982 at Baitings Dam hillclimb. bought a rebuilt one from a specialist in Chester may not be the one in the car now.

All the the best on the hills Alan.

Moto

Original Poster:

1,230 posts

252 months

Wednesday 14th August 2019
quotequote all
Cheers for that.

The diff is working fine with no noises or anything other than a slightly weeping drive shaft seal. However with just one more event to go in my second season in the TVRCC Sprint Championship I've decided to fit a Quaife ATB. I'm losing too much time spinning the inside wheel out of slow corners.

So being as I'll take the diff out it's going to get a full rebuild - either by Quaife or Jigsaw Racing. Haven't decided yet. (Andy, yes I've asked if they can drill and tap a drain plug for the reasons you've said)

Alan, if it is the same unit from 1982 - she's done pretty well. Especially considering that over the past 2 years I reckon I've done around 100 race / practice starts of dumping the clutch at 4,500 revs.

Jacking the wheel to count the turns revealed a surprise that the diff is in fact a 3.63 (I'd always assumed it was a 3.89). Maybe the 3.63 is stronger than the 3.89 ? It also explains why it is such a nice road car having slightly longer gearing.

The other surprise is how fast she has been off the line. All the events provide electronic times for the start, measuring the time taken to travel the first 64'. I will usually match the stripped out race Vixens which are 100kg lighter and have 30 ish more bhp, and also the V8 cars. The Vixens are running 4.11 diffs which on paper should also make them faster off the line. All very strange really - I can only put it down to them struggling to get traction and spinning the tyres more.

All good fun though.