WTF is this lever supposed to attach to?
WTF is this lever supposed to attach to?
Author
Discussion

2Munkys

Original Poster:

1,228 posts

266 months

Friday 30th April 2010
quotequote all


To the left of the heater/battery gubbins, what's this lever supposed to be attached to? It's fixed to the inside of the front wing by a knuckle and short rod. At the end of that is this lever. Obviously the screw pinches up against a spindle. Its difficult to get my hands in for a feel but wherever it's supposed to go, it's gonna be a ball-ache to re-attach!

Edited by 2Munkys on Friday 30th April 13:17

TVR Beaver

2,874 posts

209 months

Friday 30th April 2010
quotequote all
Isn't it the fresh air vent from the inner wing?...
I need to look at my cars''' was like an oven coming back from Chatsworth... Guess I may have the same problem??

paulathome

686 posts

247 months

Friday 30th April 2010
quotequote all
It looks to me like the linkage between the water valve for the heater and the motor which controls it, or the rod might go to one of the flaps which control air flow around the dash The motor is the round black thing with the red wire going into the back of it. On the other side of it should be an offset wheel or arm which the linkage attaches to. Not sure as mine is different.
If you need a new motor I have one somewhere brand new which was sent to me by mistake for my Chim, but then I found out the Chim heater is controlled by less sophisticated cables.
Paul

Green Griffith

29 posts

197 months

Friday 30th April 2010
quotequote all
At my ´94 Griffith this lever moves a flap that leads air from the inner wing to the footwell.

Adrian@

4,626 posts

311 months

Friday 30th April 2010
quotequote all
Recirculation flap limit stop....2ba bolt with a bit of washer hose on to make it look pretty? I might be wrong, does it rotate and hit the micro switch....
Adrian@

Edited by Adrian@ on Friday 30th April 14:46

spend

12,581 posts

280 months

Friday 30th April 2010
quotequote all
Chill out Bruce! You'll quickly become a qualified member of the flea gynaecologist club rofl

Pasco

6,652 posts

257 months

Friday 30th April 2010
quotequote all
Have you sent your rev counter off yet Bruce wink

2Munkys

Original Poster:

1,228 posts

266 months

Friday 30th April 2010
quotequote all
Pasco said:
Have you sent your rev counter off yet Bruce wink
I'm expecting it back any day; it's been over a month now.

2Munkys

Original Poster:

1,228 posts

266 months

Friday 30th April 2010
quotequote all
Here's another shot or two. Good job I have such a tiny Pentax! But I'm never get my fist in there!




2Munkys

Original Poster:

1,228 posts

266 months

Friday 30th April 2010
quotequote all
Adrian@ said:
Recirculation flap limit stop....2ba bolt with a bit of washer hose on to make it look pretty? I might be wrong, does it rotate and hit the micro switch....
Adrian@


Edited by Adrian@ on Friday 30th April 14:46
Other than giving me a headache and wrist-ache it's doin' diddly squat.

Pasco

6,652 posts

257 months

Friday 30th April 2010
quotequote all
2Munkys said:
Pasco said:
Have you sent your rev counter off yet Bruce wink
I'm expecting it back any day; it's been over a month now.
Let me know what sort of job you recon they have done mate and if ok i will send my spare one then thumbup

Guillotine

5,516 posts

293 months

Friday 30th April 2010
quotequote all
back side of that motor plate is a little crank arangement that attaches to that linkage.

think heater valve motor, circulates and pulls the flap shut via that linkage.

undo the bolts top and bottom to release motor plate, disconnect the linkage from plate.

attach the the linkage to the crank on the motor. loosely bolt plate back on

attach the linkage to the plate and do it all up...pain in the butt.

2Munkys

Original Poster:

1,228 posts

266 months

Friday 30th April 2010
quotequote all
Guillotine said:
back side of that motor plate is a little crank arangement that attaches to that linkage.

think heater valve motor, circulates and pulls the flap shut via that linkage.

undo the bolts top and bottom to release motor plate, disconnect the linkage from plate.

attach the the linkage to the crank on the motor. loosely bolt plate back on

attach the linkage to the plate and do it all up...pain in the butt.
Thanks Andy, I've just tyre-levered myself out of the footwell after a bit of feeling around and came to the conclusion you describe. It's a cool air vent flap mechanism. I can feel two limit switches and a spindle on the back of the plate. Either the crank/lever or the long pinch-screw contact the limit switches.

Which of the controls operate the motor? I've fiddled with 'em all and I can here things whirring away but those motors stop in relation to the rotary switch position. So it's none of those. I'd expect to be able to feel the spindle rotating and hear the motor. If I whip the battery out tomorrow then I'll take some shots to post-up.

BigotOut

72,863 posts

268 months

Saturday 1st May 2010
quotequote all
Hot cold is top left, fan is top right, recirc is bottom left and dash screen is bottom right. The limit switches are on the motors, not on the flaps so the switches probably believe everything is still operating.

Del 203

12,728 posts

278 months

Saturday 1st May 2010
quotequote all
BigotOut said:
Just seen the name change rofl

Mr MoJo

4,698 posts

245 months

Saturday 1st May 2010
quotequote all
Del 203 said:
BigotOut said:
Just seen the name change rofl
hehe I like it !!

BigotOut

72,863 posts

268 months

Sunday 2nd May 2010
quotequote all
Bigot = Brown Is Gone On Thursday biggrin

2Munkys

Original Poster:

1,228 posts

266 months

Tuesday 4th May 2010
quotequote all
Job done. All workin' as intended; it took about an hour. I can't see how this thing could have detatched itself! And, I have no idea how long it'd been detached!




Rob_the_Sparky

1,000 posts

267 months

Tuesday 4th May 2010
quotequote all
Did you come to a conclusion as to exactly what this does? I've got to do the contortion act at somepoint on mine as I'm sure my fresh/re-circ control does nothing and the heater has the classic warm - hot control issue.

2Munkys

Original Poster:

1,228 posts

266 months

Wednesday 5th May 2010
quotequote all
^

Yup, the motor turns the crank which opens/closes the flap (brown sponge covered panel you see there) via the push/pull rod. The micro-switches are the fully open/closed limit switches which the long screw operates. Effectively the flap mechanism is a valve which allows you to proportion the amount of cooling fresh air into the footwell through one of the rotary pots on the heater panel. I forget whether it was the top or bottom left control; whatever, I was overjoyed to see it function and lay there contorted in the foot-well with a smile on my face. I think the Chim' version is cable operated; that wouldn't make a funky buzzing sound though.

You should be able to see if it's operating without removing anything other than the carpeted battery compartment cover panel. If you do need to get easy access however, I'd remove the battery as I did.

Edited by 2Munkys on Wednesday 5th May 08:40