GT3 warranty renewal - front discs
Discussion
Car has just failed the warranty inspection and needs new discs as there are 'cracks above 5mm and blocked vents'.
Just taken it back and had a look and slightly bemused WRT cracking, but happy to be educated? Are the rear faces more likely to be any worse?
Car has done about a 6 track days with me and I usually do 12 lap sessions and a full lap to cool down.





Just taken it back and had a look and slightly bemused WRT cracking, but happy to be educated? Are the rear faces more likely to be any worse?
Car has done about a 6 track days with me and I usually do 12 lap sessions and a full lap to cool down.
New Porsches must be a tad soft. I can stay out on circuit for over 30mins in the old 996 GT3 
It is an unfortunate side effect of the 111p check that they will condemn the disks for cracks which most independents would pass. You could drive them yet for many more track days.
In my experience the OPC would give an advisory but still pass the car for warranty renewal as the brakes aren’t covered by the warranty anyway.
I’ve taken cars with delaminating PCCBs before and it’s been ok for renewal. Looks like you’ve got a jobsworth OPC centre. Ideally one should show something like that to them first before the check to confirm they will still pass it. That way you chose your opc before the test.
Edited to add: in my experience OPCs have been more bothered about the discs having a Porsche 996.xxx / 997.xxx or 991.xxx part number on them than the state of the actual discs. You should impress upon them that this is a 111 point check for warranty renewal and not resale (for which the discs might fail the Porsche standard). For warranty renewal those discs have zero additional liability for Porsche.

It is an unfortunate side effect of the 111p check that they will condemn the disks for cracks which most independents would pass. You could drive them yet for many more track days.
In my experience the OPC would give an advisory but still pass the car for warranty renewal as the brakes aren’t covered by the warranty anyway.
I’ve taken cars with delaminating PCCBs before and it’s been ok for renewal. Looks like you’ve got a jobsworth OPC centre. Ideally one should show something like that to them first before the check to confirm they will still pass it. That way you chose your opc before the test.
Edited to add: in my experience OPCs have been more bothered about the discs having a Porsche 996.xxx / 997.xxx or 991.xxx part number on them than the state of the actual discs. You should impress upon them that this is a 111 point check for warranty renewal and not resale (for which the discs might fail the Porsche standard). For warranty renewal those discs have zero additional liability for Porsche.
Edited by LaSource on Saturday 14th December 17:34
LaSource said:
New Porsches must be a tad soft. I can stay out on circuit for over 30mins in the old 996 GT3 
It is an unfortunate side effect of the 111p check that they will condemn the disks for cracks which most independents would pass. You could drive them yet for many more track days.
In my experience the OPC would give an advisory but still pass the car for warranty renewal as the brakes aren’t covered by the warranty anyway.
I’ve taken cars with delaminating PCCBs before and it’s been ok for renewal. Looks like you’ve got a jobsworth OPC centre. Ideally one should show something like that to them first before the check to confirm they will still pass it. That way you chose your opc before the test.
This makes sense - surely the OPC can honour the warranty as the discs wouldn’t be covered. It may be worth escalating your plight to the Service Manager as I wouldn’t accept what they are saying
It is an unfortunate side effect of the 111p check that they will condemn the disks for cracks which most independents would pass. You could drive them yet for many more track days.
In my experience the OPC would give an advisory but still pass the car for warranty renewal as the brakes aren’t covered by the warranty anyway.
I’ve taken cars with delaminating PCCBs before and it’s been ok for renewal. Looks like you’ve got a jobsworth OPC centre. Ideally one should show something like that to them first before the check to confirm they will still pass it. That way you chose your opc before the test.
They are nothing to worry about and I would politely ask for a second opinion from someone a bit more knowledgeable at the OPC so you can pass your warranty check. Last time I spoke to a technician , they worked to a 5mm rule for the cracks that propagate from the drilled holes. They do not look anywhere near 5mm.
These were mine after same amount of trackdays but I didn't need anyone to tell me to change them

These were mine after same amount of trackdays but I didn't need anyone to tell me to change them

My GT4 failed warranty check on the same basis, though cracks were worse than it looks like in your pics. My indy said they wouldn't replace at that point, but they would recommending changing once the pads were done (about 50% worn). I bit the bullet and changed to get the warranty - has probably worked OK for me as I've subsequently had two warranty claims.
Agree with others that it may be worth you getting another opinion (either same or different OPC), especially if you clean the cooling holes out first.
Agree with others that it may be worth you getting another opinion (either same or different OPC), especially if you clean the cooling holes out first.
nudgerwilliams said:
My GT4 failed warranty check on the same basis, though cracks were worse than it looks like in your pics. My indy said they wouldn't replace at that point, but they would recommending changing once the pads were done (about 50% worn). I bit the bullet and changed to get the warranty - has probably worked OK for me as I've subsequently had two warranty claims.
Agree with others that it may be worth you getting another opinion (either same or different OPC), especially if you clean the cooling holes out first.
Agree clean the holes .... or a warranty set , maybe a group of PH owners have a set that we share , just for warranty day Agree with others that it may be worth you getting another opinion (either same or different OPC), especially if you clean the cooling holes out first.
Thanks for your replies - mostly as I hoped/expected.
If those discs needed changing already with my modest track ability, then I would have had concerns about the product.
As it stands I am less impressed with the warranty criteria as it needed two new rears - they could only get N1, but my front axle still had N0 so another unexpected expense. But it is what it is.
Currently deciding whether to keep hold of it or switch as I've had it just over two years and be good to experience something different. If I keep it I will talk to my OPC again.
If those discs needed changing already with my modest track ability, then I would have had concerns about the product.
As it stands I am less impressed with the warranty criteria as it needed two new rears - they could only get N1, but my front axle still had N0 so another unexpected expense. But it is what it is.
Currently deciding whether to keep hold of it or switch as I've had it just over two years and be good to experience something different. If I keep it I will talk to my OPC again.
ChrisW. said:
I'm with Cunno on this.
Does the OPC think he has you by the short and curlies ?
Nothing wrong with them on these faces. Not sure what the backsides look like it can’t imagine they’d be any worse. Does the OPC think he has you by the short and curlies ?
Go to a different OPC.
Mine look much worse than that and my OPC said they’d pass it, knowing that'd I’ll be replacing them soon anyway.
Edited by TDT on Wednesday 18th December 23:39
They look fine to me too...
mind you I nearly had a heart attack when mine went in for its warranty renewal;
F&R PCCB discs 'subject to heat' recommend replacing
Pads 9mm all round - subject to heat - suggest replacing
cost for both - £21K !!
interesting point is that I've actually only done one (lazy) trackday this year, rather than the 6/7
Also looking at last years report, the pads were all at 8mm, and no replacement recommendation.
I also had the F&R N1 / N0 issue.
Luckily I have a good relationship with he OPC, and they let this one slide...
mind you I nearly had a heart attack when mine went in for its warranty renewal;
F&R PCCB discs 'subject to heat' recommend replacing
Pads 9mm all round - subject to heat - suggest replacing
cost for both - £21K !!
interesting point is that I've actually only done one (lazy) trackday this year, rather than the 6/7
Also looking at last years report, the pads were all at 8mm, and no replacement recommendation.
I also had the F&R N1 / N0 issue.
Luckily I have a good relationship with he OPC, and they let this one slide...

nw942 said:
Not sure why they didn't show any flexibility WRT the discs and tyres - bit short-term in their thinking.
Yep - exactly. I said this to my OPC, and they'd pass the car knowing that I'd be replace those consumables in short order anyway, as use the car on track.As it is, I haven't bothered with extended warranty, at this stage anyway.
Gassing Station | 911/Carrera GT | Top of Page | What's New | My Stuff


